EV Services & Diagnostics Menu
Transparent flat-rate labor and OEM diagnostic testing across all EV Doctor Center franchise locations. Every high-voltage service includes our OSHA NFPA 70E safety sign-off.
High-Voltage Traction Battery Systems
Comprehensive cell-level health diagnostic, SOH measurement, cell balancing, pyro-fuse safety, and module rejuvenation.
Complete EV Battery SOH & Digital Health Passport
$289.00Diagnostic scan of all series cell groups, delta millivolt variance, thermal baseline, insulation resistance test (>500MΩ), and certified digital certificate.
High-Voltage Cell Active Balancing & Rejuvenation
$749.00Direct bench balancing of weak cell blocks using precision micro-charge/discharge algorithms to eliminate pack capacity throttle.
Pyrotechnic Battery Disconnect / Pyro-Fuse Service
$420.00Post-fault or periodic replacement of high-speed pyrotechnic battery safety fuse and high-voltage contactor inspection.
Electric Motors & Inverters
Silicon-Carbide (SiC) inverter diagnostics, resolver alignment, stator resistance testing, and reduction gearbox fluid servicing.
SiC Inverter & Power Electronics Diagnostic Protocol
$550.00IGBT/MOSFET switching frequency test, gate driver voltage verification, and thermal compound renewal.
Thermal Management & Heat Pumps
Dielectric coolant loop flushes, octovalve diagnostics, chiller heat exchanger servicing, and cabin heat pump overhaul.
Dielectric Low-Conductivity Battery Coolant Flush
$360.00Vacuum evacuation and refill with OEM ultra-low conductivity glycol coolant preventing internal battery electrical arcing.
Charging Systems & Telematics
On-Board Charger (OBC) AC/DC testing, DC Fast-Charge inlet actuator replacement, BMS firmware calibration, and CAN-bus debug.
DC Fast Charge (NACS/CCS) Port & Locking Solenoid Repair
$310.00Overheating terminal replacement, pilot communication line troubleshooting, and motorized latch servo replacement.
Regenerative Braking & EV Chassis
Low-drag EV caliper de-seizing, synthetic high-boiling brake fluid flush, and acoustic EV-rated tire dynamic balancing.
EV Regenerative Brake Caliper Lubrication & DOT 5.1 Flush
$240.00Slide pin rust abatement, ceramic pad chamfering, and high-boiling low-viscosity brake fluid flush for EV regenerative systems.